侧流电除尘增效机理与检验
Collection enhancement mechanism and test of side flow electrostatic precipitation
-
摘要: 针对现有许多电除尘器难以满足日益严苛的颗粒物排放要求而面临提效改造的现状，根据经典电除尘理论，降低电场风速是电除尘器提效的一个有效途径，进而提出一种通过改变烟气流向成倍降低电场风速的侧流电除尘器。首先，为阐明侧流电除尘器的增效机理，基于已有的关于紊流情况下流速对颗粒悬浮作用的研究结果，通过受力分析给出了在有悬浮升力影响下带电颗粒的电除尘效率理论表达式，证明了降低电场风速的增效作用比增加电场长度更有效。然后，在极配结构和处理流量相同、平均入口含尘浓度约1 400 mg·m-3和场强在2.5~4.5 kV·cm-1的情况下，采用中位径为3.5 μm的硅微粉进行了侧流电除尘器和常规电除尘器的减排效果对比实验研究。结果表明，侧流电除尘器的平均排放浓度比常规电除尘器降低45％，减排作用突出。Abstract: Nearly all electrostatic precipitators (ESPs) have to be reformed to improve the collection performance nowadays since the particulate emission standard is becoming more and more rigorous. According to the classical collection theory, it is noticed obviously that to reduce the gas velocity in the electric field is one of the most effective ways of the collection efficiency enhancement. Thus, a side flow ESP is proposed. The gas velocity in the electric field of this ESP can be greatly reduced while the gas flow rate keeps no change. Firstly, based on the results of other researchers about the relation of the lift force and gas velocity in turbulent flow, a theoretical expression of the collection efficiency is derived from the balance equation of the lift force and the electric force acting upon the charged particles. It is proved that the efficiency enhancement effect of decreasing the gas velocity in the electric field is more effective than that of increasing the field length. And then, the comparison experiment of the collection efficiency is carried out. The silica powder with 3.5 μm medium diameter is used in the experiment. The average inlet dust concentration is about 1 400 mg·m-3. The electric field strength is in the range from 2.5 to 4.5 kV·cm-1. The experimental results have shown that the emission concentration of side flow ESP is 45% lower than that of the conventional ESP under the same electrode configuration and gas flow rate.
-
-
[1] 中国环境保护产业协会电除尘委员会.电除尘行业2015年发展综述[J].中国环保产业,2016,22(7):16-25 [2] HE Z J, MOHAN E T, KARTHIK G.Design of electrostatic precipitator to remove suspended micro particulate matter from gas turbine inlet airflow: Part I.Experimental study[J].Journal of Aerosol Science, 2017.108(6):14-28 [3] 胡志光,贾博强.中国电除尘器与袋式除尘器的现状比较与分析[J].环境科学与管理,2012,28(12):60-68 [4] 环境保护部,国家质量监督检验检疫总局.钢铁烧结,球团工业大气污染物排放标准：GB 28664-2012[S].北京:中国环境出版社,2012 [5] 张滨渭.燃煤电场烟尘排放状况及分析[C]//中国环境保护产业协会电除尘委员会.第15届中国电除尘学会会议论文集. 2013:237-245 [6] MASUDA S.Handbook of Electrostatic Process (Electrostatic Precipitation)[M].New York:Marcel Dekker, 1997 [7] GOLKOWSKI C, CHOJNOWSKI M.The role of electrode spacing in the performance of the electrostatic precipitator[J].Journal of Electrostatics, 1983, 14(3): 339-348 [8] KOIZUMI Y, KAWAMURA M, TOCHIKUBO F, et al.Estimation of the agglomeration coefficient of bipolar-charged aerosol particles[J].Journal of Electrostatics, 2000, 48(2): 93-101 [9] 潘大光.带辅助电极的三电极电除尘器的基本工作原理及其应用[J].电力环境保护,1990,6(1):49-53 [10] MASUDA S, MOON J.Electrostatic precipitation of carbon soot from diesel engine exhaust[J].IEEE Transactions on Industry Applications, 1983,19(6):1104-1111 [11] XIANG X D, CHANG Y F, NIE Y T.Investigation of the performance of bipolar transverse plate ESP in the sintering flue control[J].Journal of Electrostatics,2015,76(4):18-23 [12] OGLESBY S, NICHOLS G B.电除尘器[M]. 谭天祐，译.北京:水利电力出版社,1983 [13] 邵学军,夏震寰.紊动流场中悬浮颗粒分布的随机理论[J].力学学报, 1991,33(1):28-35 [14] 王光谦,倪普仁. 再论悬移质浓度垂线分布的两种类型其产生的原因[J].水动力学研究与进展,1991,6(4):60-71 [15] MERCER T T.Aerosol technology[J].Journal of Aerosol Science,1983,14(2):175-176 -
点击查看大图
计量
- 文章访问数: 2658
- HTML全文浏览数: 2235
- PDF下载数: 314
- 施引文献: 0
下载:
