高级搜索

MFC产电辅助Fe,Ce-TiO2/Ti-Cu光催化处理染料废水

, 

downloadPDF

上一篇

下一篇

钟登杰, 徐云兰. MFC产电辅助Fe,Ce-TiO2/Ti-Cu光催化处理染料废水[J]. 环境工程学报, 2018, 12(6): 1644-1650. doi: 10.12030/j.cjee.201711120
引用本文: 钟登杰, 徐云兰. MFC产电辅助Fe,Ce-TiO2/Ti-Cu光催化处理染料废水[J]. 环境工程学报, 2018, 12(6): 1644-1650. doi: 10.12030/j.cjee.201711120
shu
ZHONG Dengjie, XU Yunlan. MFC assisted Fe,Ce-TiO2/Ti-Cu photocatalytic treatment of dye wastewater[J]. Chinese Journal of Environmental Engineering, 2018, 12(6): 1644-1650. doi: 10.12030/j.cjee.201711120
Citation: ZHONG Dengjie, XU Yunlan. MFC assisted Fe,Ce-TiO2/Ti-Cu photocatalytic treatment of dye wastewater[J]. Chinese Journal of Environmental Engineering, 2018, 12(6): 1644-1650. doi: 10.12030/j.cjee.201711120
shu

MFC产电辅助Fe,Ce-TiO2/Ti-Cu光催化处理染料废水

  • 1.

    重庆理工大学化学化工学院，重庆 400054

  • 基金项目:

MFC assisted Fe,Ce-TiO2/Ti-Cu photocatalytic treatment of dye wastewater

  • 1.

    School of Chemical Engineering, Chongqing University of Technology, Chongqing 400054, China

  • Fund Project:

  • 摘要: 采用溶胶-凝胶法制备了Fe,Ce-TiO2/Ti膜电极，通过正交实验考察了该电极的最佳制备条件为550 ℃煅烧、掺杂摩尔比n(Fe:Ti）=6%和n(Ce:Ti）=3%。其X射线衍射(XRD)和紫外-可见漫反射(DRS)分析表明，催化剂晶型为锐钛矿，Fe、Ce掺杂抑制了晶粒的生长和金红石相的生成，使催化剂有明显的可见光响应。以Fe,Ce-TiO2/Ti为光阳极，Cu为阴极，并以微生物燃料电池(MFC)为外加电源，组装MFC电助Fe,Ce-TiO2/Ti-Cu光催化反应器，在可见光下光电催化(MPEC)处理活性艳红X-3B(RBR)。MPEC与自生电场光电催化(SPEC)和外加电场光电催化(PEC)的对比结果表明MPEC是可行的，它比SPEC的脱色率高9%，与PEC相当，但能耗更低。考察了MPEC的主要影响因素，得出最佳条件为2组MFC串联，废水流量80 mL·min-1，废水初始pH 2.56。在太阳光下，MPEC能使RBR有效脱色，处理100 min的脱色率可达87%。紫外-可见分光光谱分析表明，MPEC能使RBR的发色基团迅速遭到破坏。
    Abstract: Fe,Ce-TiO2/Ti thin-film electrodes have been prepared by sol-gel method. The optimum preparation conditions of the electrodes were investigated by orthogonal experiments, and they were calcined at 550 ℃, doped with mole ratio n (Fe:Ti) =6% and n (Ce:Ti) =3%. The X-ray diffraction (XRD) and UV-vis diffuse reflectance spectroscopy (DRS) characterization of the electrode demonstrates the photocatalyst is anatase, Fe and Ce doping inhibited the grain growth and the rutile formation, and extended its light response wavelength to visible region. Using the prepared Fe,Ce-TiO2/Ti as photoanode and Cu as cathode, and the microbial fuel cell (MFC) as external power supply, the MFC assisted Fe,Ce-TiO2/Ti-Cu photocatalytic reactor was assembled to photoelectrocatalytic (MPEC) treat reactive brilliant red X-3B (RBR) under visible light irradiation. The main influence factors were investigated. The obtained optimal conditions are two groups of MFCs series, wastewater circulating flux 80 mL·min-1 and wastewater initial pH 2.56. Under the sun light irradiation, MPEC can decolorize RBR effectively, and the decolorization efficiency reached to 87% for 100 min treatment. UV-vis spectra analysis demonstrates the MPEC can rapidly destroy the RBR chromophore.
  • 加载中
  • [1] WANG D W, LI Y, GIANLUCA L P, et al.Dye-sensitized photoelectrochemical cell on plasmonic Ag/AgCl @ chiral TiO2 nanofibers for treatment of urban wastewater effluents, with simultaneous production of hydrogen and electricity[J].Applied Catalysis B: Environmental,2015,168-169:25-32 10.1016/j.apcatb.2014.11.012
    [2] 贾陈忠,刘松,张彩香,等.光催化氧化降解垃圾渗滤液中溶解性有机物[J]. 环境工程学报,2013,7(2):451-456
    [3] 沈文浩,刘天龙,李翠翠,等.TiO2 胶体光催化降解罗丹明 B 染料[J].环境工程学报,2012,7(2):1863-1870
    [4] VAIANO V, SACCO O, SANNINO D, CIAMBELLI P.PN-doped TiO2 photocatalysts[J].Chemical Engineering Journal,2015,261:3-8 10.1016/j.cej.2014.02.071
    [5] JIA Y H, YE L, KANG X, et al.Photoelectrocatalytic reduction of perchlorate in aqueous solutions over Ag doped TiO2 nanotube arrays[J].Journal of Photochemistry Photobiology A: Chemistry,2016,328:225-232 10.1016/j.jphotochem.2016.05.023
    [6] RENATA P S, THáBATA K F S F, FERNANDO S D, et al.Photocatalytic activity of TiO2, ZnO and Nb2O5 applied to degradation of textile wastewater[J].Journal of Photochemistry Photobiology A: Chemistry,2016,329:9-17 10.1016/j.jphotochem.2016.06.013
    [7] WANG YM, HU B, HU C L, et al.Fabrication of a novel Ti/SnO2–Sb–CeO2@TiO2–SnO2 electrode and photoelectrocatalytic application in wastewater treatment[J].Materials Science in Semiconductor Processing,2015,40:744-751 10.1016/j.mssp.2015.06.020
    [8] ZHOU Q X, XING A, LI J, et al.Synergistic enhancement in photoelectrocatalytic degradation of bisphenol A by CeO2 and reduced graphene oxide co-modified TiO2 nanotube arrays in combination with Fenton oxidation[J].Electrochimica Acta,2016,209:379-388 10.1016/j.electacta.2016.05.094
    [9] CQIAO Y.Carbon nanotube/polyaniline composite as anode material for microbial fuel cells[J].Journal of Power Sources,2007,170(1):79-84 10.1016/j.jpowsour.2007.03.048
    [10] XU Y L, ZHONG D J, JIA J P, et al.Dual slant-placed electrodes thin-film photocatalytic reactor: Enhanced dye degradation efficiency by self-generated electric field[J].Chemical Engineering Journal,2013,225:138-143 10.1016/j.cej.2013.03.085
    [11] YUAN S J, SHENG G P, LI W W, et al.Degradation of organic pollutants in a photoelectrocatalytic system enhanced by a microbial fuel cell[J].Environmental Science & Technology,2010,44(10):5570-5585 10.1021/es101317z
    [12] 徐云兰,李珏秀,钟登杰,等.双极液膜法可见光光催化降解染料废水[J].中国环境科学,2014,34(6):1463-1470 10.3969/j.issn.1000-6923.2014.06.014
    [13] XU Y L, HE Y, CAO X D, et al.TiO2/Ti rotating disk photoelectrocatalytic (PEC) reactor: A combination of highly effective thin-film PEC and conventional PEC processed on a single electrode[J].Environmental Science & Technology,2008,42(7):2612-2617 10.1021/es702921h
    [14] SIVA N R I,THIRUPATHI B, MAKRAM S, et al.Visible-light-induced photodegradation of gas phase acetonitrile using aerosol-made transition metal (V, Cr, Fe, Co, Mn, Mo, Ni, Cu, Y, Ce, and Zr) doped TiO2[J].Applied Catalysis B: Environmental,2014,144:333-342 10.1016/j.apcatb.2013.07.032
    [15] XU Y L, JIA J P, ZHONG D J, et al.Degradation of dye wastewater in a thin-film phtotoelectrocatalytic (PEC) reactor with slant-placed TiO2/Ti anode[J].Chemical Engineering Journal,2009,150(2/3): 302-307 10.1016/j.cej.2009.01.002
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  3176
  • HTML全文浏览数:  2724
  • PDF下载数:  364
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-06-18

MFC产电辅助Fe,Ce-TiO2/Ti-Cu光催化处理染料废水

  • 1. 重庆理工大学化学化工学院，重庆 400054
基金项目:

摘要: 采用溶胶-凝胶法制备了Fe,Ce-TiO2/Ti膜电极，通过正交实验考察了该电极的最佳制备条件为550 ℃煅烧、掺杂摩尔比n(Fe:Ti）=6%和n(Ce:Ti）=3%。其X射线衍射(XRD)和紫外-可见漫反射(DRS)分析表明，催化剂晶型为锐钛矿，Fe、Ce掺杂抑制了晶粒的生长和金红石相的生成，使催化剂有明显的可见光响应。以Fe,Ce-TiO2/Ti为光阳极，Cu为阴极，并以微生物燃料电池(MFC)为外加电源，组装MFC电助Fe,Ce-TiO2/Ti-Cu光催化反应器，在可见光下光电催化(MPEC)处理活性艳红X-3B(RBR)。MPEC与自生电场光电催化(SPEC)和外加电场光电催化(PEC)的对比结果表明MPEC是可行的，它比SPEC的脱色率高9%，与PEC相当，但能耗更低。考察了MPEC的主要影响因素，得出最佳条件为2组MFC串联，废水流量80 mL·min-1，废水初始pH 2.56。在太阳光下，MPEC能使RBR有效脱色，处理100 min的脱色率可达87%。紫外-可见分光光谱分析表明，MPEC能使RBR的发色基团迅速遭到破坏。

English Abstract

    全文HTML

参考文献 (15)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心