高级搜索

基于硫酸亚铁的机械化学还原法处理六价铬污染土壤

,  ,  ,  ,  ,  ,  ,  , 

downloadPDF

上一篇

下一篇

许维通, 张紫薇, 苑文仪, 李培中, 王临才, 王晓岩, 张承龙, 白建峰, 王景伟. 基于硫酸亚铁的机械化学还原法处理六价铬污染土壤[J]. 环境工程学报, 2018, 12(6): 1759-1765. doi: 10.12030/j.cjee.201711219
引用本文: 许维通, 张紫薇, 苑文仪, 李培中, 王临才, 王晓岩, 张承龙, 白建峰, 王景伟. 基于硫酸亚铁的机械化学还原法处理六价铬污染土壤[J]. 环境工程学报, 2018, 12(6): 1759-1765. doi: 10.12030/j.cjee.201711219
shu
XU Weitong, ZHANG Ziwei, YUAN Wenyi, LI Peizhong, WANG Lincai, WANG Xiaoyan, ZHANG Chenglong, BAI Jianfeng, WANG Jingwei. Treatment of Cr(VI)-contaminated soil through mechanochemical reduction with ferrous sulfate[J]. Chinese Journal of Environmental Engineering, 2018, 12(6): 1759-1765. doi: 10.12030/j.cjee.201711219
Citation: XU Weitong, ZHANG Ziwei, YUAN Wenyi, LI Peizhong, WANG Lincai, WANG Xiaoyan, ZHANG Chenglong, BAI Jianfeng, WANG Jingwei. Treatment of Cr(VI)-contaminated soil through mechanochemical reduction with ferrous sulfate[J]. Chinese Journal of Environmental Engineering, 2018, 12(6): 1759-1765. doi: 10.12030/j.cjee.201711219
shu

基于硫酸亚铁的机械化学还原法处理六价铬污染土壤

  • 1.

    上海第二工业大学环境与材料工程学院，上海 201209

  • 2.

    上海电子废弃物资源化创新协调中心，上海第二工业大学电子废弃物研究中心，上海 201209

  • 3.

    北京轻工业环境保护研究所工业场地污染与修复北京市重点实验室，北京 100089

  • 基金项目:

    国家自然科学基金资助项目(21407105)

    上海第二工业大学研究生项目基金资助项目（A01GY17F022）

    上海第二工业大学校级特色-飞跃计划项目资助（EGD18XQD27）

    上海第二工业大学学科建设基金资助项目（A20NH1609B10-2）

Treatment of Cr(VI)-contaminated soil through mechanochemical reduction with ferrous sulfate

  • 1.

    School of Environmental and Materials Engineering, Shanghai Polytechnic University, Shanghai 201209, China

  • 2.

    WEEE Research Centre of Shanghai Polytechnic University, Shanghai Collaborative Innovation Centre for Waste Electrical and Electronic Equipment Recycling, Shanghai 201209, China

  • 3.

    Beijing Key Laboratory of Industrial Land Contamination and Remediation, Environmental Protection Research Institute of Light Industry, Beijing 100089, China

  • Fund Project:

  • 摘要: 通过机械化学还原法对六价铬污染土壤进行固化稳定化处理，采用《固体废物 浸出毒性浸出方法 硫酸硝酸法》（HJ/T 299-2007）对处理效果进行评价，以及使用激光粒度仪、SEM和XPS对处理前后土壤样品的粒径、形貌以及铬的价态变化等性质进行表征。分析结果显示，机械化学还原法处理可以有效降低土壤中六价铬的浸出浓度。当未添加七水合硫酸亚铁时，土壤中六价铬的浸出浓度由115 mg·L-1降低至2.0 mg·L-1；而添加七水合硫酸亚铁作为还原剂时，六价铬浸出浓度由115 mg·L-1降至0.16 mg·L-1。另外，经过机械化学还原处理后的土壤样品颗粒变细并形成致密的团聚体以及发生六价铬向三价铬的转化。
    Abstract: In this research, the solidification and stabilization treatment of Cr(Ⅵ)-contaminated soil through mechanochemical reduction with ferrous sulfate was investigated. The properties of soil after remediation by ball milled with or without ferrous sulfate were characterized by XRD, SEM and XPS analysis. And the leachable fraction of Cr(Ⅵ) from the treated samples is also analyzed through the method HJ/T 299-2007. The results indicate that mechanochemical remediation is very effective for the solidification and stabilization of Cr(Ⅵ)-contaminated soil. Cr(Ⅵ) leaching concentration decreased from 115 to 2.0?and 0.16?mg·-1, respectively, when without and with ferrous sulfate. In addition, during mechanochemical treatment, decrease in particle size, agglomeration and the conversion between Cr(Ⅵ) and Cr(Ⅲ) in contaminated soil are observed.
  • 加载中
  • [1] GRAHAM A M, WADHAWAN A R, BOUWER E J.Chromium occurrence and speciation in Baltimore Harbor sediments and porewater,Baltimore,Maryland, USA[J].Environmental Toxicology & Chemistry,2009,28(3):471-480 10.1897/08-149.1
    [2] LINDSAY D R, FARLEY K J, CARBONARO R F.Oxidation of Cr(III) to Cr(VI) during chlorination of drinking water[J].Journal of Environmental Monitoring, 2012, 14(7):1789-1797 10.1039/C2EM00012A
    [3] APTE A D, TARE V, BOSE P.Extent of oxidation of Cr(III) to Cr(VI) under various conditions pertaining to natural environment[J].Journal of Hazardous Materials, 2006,128(2/3):164-174 10.1016/j.jhazmat.2005.07.057
    [4] WANG Y, FANG Z, LIANG B, et al.Remediation of hexavalent chromium contaminated soil by stabilized nanoscale zero-valent iron prepared from steel pickling waste liquor[J].Chemical Engineering Journal,2014,247(6):283-290 10.1016/j.cej.2014.03.011
    [5] 崔永高.铬污染土壤和地下水的修复技术研究进展[J].工程地质学报,2017,25(4):1001-1009 10.13544/ j.cnki.jeg.2017.04.014
    [6] 周加祥,刘铮.铬污染土壤修复技术研究进展[J].环境工程学报,2000,1(4):52-56
    [7] 张蕊.六价铬在土壤中迁移转化影响因素研究及风险评价[D].长春：吉林大学,2013
    [8] 姜苹红,陈灿,向仁军.铬污染土壤的单一/复合还原处理及其长期稳定性研究[J].环境工程学报,2015,9(10):5091-5095
    [9] 黄莹,徐民民,李书鹏,等.还原稳定化法修复六价铬污染土壤的中试研究[J].环境工程学报,2015, 9(2):951-958
    [10] DENG S, KANG S, FENG N, et al.Mechanochemical mechanism of rapid dechlorination of hexachlorobenzene[J].Journal of Hazardous Materials,2017,333:116-154 10.1016/j.jhazmat.2017.03.022
    [11] ZHANG W, WANG H, HUANG J, et al.Acceleration and mechanistic studies of the mechanochemical dechlorination of HCB with iron powder and quartz sand[J].Chemical Engineering Journal,2014,239(3):185-191 10.1016/j.cej.2013.11.018
    [12] MONTINARO S, CONCAS A, PISU M, et al.Rationale of lead immobilization by ball milling in synthetic soils and remediation of heavy metals contaminated tailings[J].Chemical Engineering Journal, 2009, 155(1):123-131 10.1016/j.cej.2009.07.005
    [13] MONTINARO S, CONCAS A, PISU M, et al.Immobilization of heavy metals in contaminated soils through ball milling with and without additives[J].Chemical Engineering Journal,2008,142(3):271-284 10.1016/j.cej.2007.12.003
    [14] ZHANG Z X.Immobilisation of metal in quartz sands by ball milling[D].Auckland: Auckland University of Technology, 2008
    [15] CONCAS A, MONTINARO S, PISU M, et al.Mechanochemical remediation of heavy metals contaminated soils: Modelling and experiments[J].Chemical Engineering Science,2007, 62(18/19/20):5186-5192 10.1016/j.ces.2007.02.024
    [16] USEPA.Test methods for evaluating solid waste, physical/chemical methods,SW-846:Method 3050B[S].Washington, D.C. , 1992
    [17] CEPA.Solid waste extraction procedure for leaching toxicity sulfuric acid & nitric acid method:HJ/T299-2007[S].2007
    [18] SANTHANAM P R, DREIZIN E L.Predicting conditions for scaled-up manufacturing of materials prepared by ball milling[J].Powder Technology,2012,221(5):403-411 10.1016/j.powtec.2012.01.037
    [19] DELOGU F, ORRù R, CAO G.A novel macrokinetic approach for mechanochemical reactions[J].Chemical Engineering Science,2003,58(3):815-821 10.1016/S0009-2509(02)00612-7
    [20] BOURSIQUOT S, MULLET M, EHRHARDT J J.XPS study of the reaction of chromium (VI) with mackinawite (FeS)[J].Surface & Interface Analysis,2010,34(1):293-297 10.1002/sia.1303
    [21] AND L D, GUILLON E.Removal of hexavalent chromium with a lignocellulosic substrate extracted from wheat bran[J].Environmental Science & Technology,2003,37(18):4235-4241 10.1021/es0342345
    [22] ZHANG W X, LI X Q, CAO J S.Reply to comments on stoichiometry of Cr (VI) immobilization using nanoscale zerovalent iron (nZVI): A study with high-resolution X-ray photoelectron spectroscopy (HR-XPS)[J].Industrial & Engineering Chemistry Research,2009,47(7):2297-2297 10.1021/ie061655x
    [23] LEGRAND L, EL F A, MERCIER F, et al.Reduction of aqueous chromate by Fe(II)/Fe(III) carbonate green rust: kinetic and mechanistic studies[J].Environmental Science & Technology,2004,38(17):4587-4595 10.1021/es035447x
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  2957
  • HTML全文浏览数:  2585
  • PDF下载数:  378
  • 施引文献:  0
出版历程
  • 刊出日期:  2018-06-18

基于硫酸亚铁的机械化学还原法处理六价铬污染土壤

  • 1. 上海第二工业大学环境与材料工程学院，上海 201209
  • 2. 上海电子废弃物资源化创新协调中心，上海第二工业大学电子废弃物研究中心，上海 201209
  • 3. 北京轻工业环境保护研究所工业场地污染与修复北京市重点实验室，北京 100089
基金项目:

国家自然科学基金资助项目(21407105)

上海第二工业大学研究生项目基金资助项目（A01GY17F022）

上海第二工业大学校级特色-飞跃计划项目资助（EGD18XQD27）

上海第二工业大学学科建设基金资助项目（A20NH1609B10-2）

摘要: 通过机械化学还原法对六价铬污染土壤进行固化稳定化处理，采用《固体废物 浸出毒性浸出方法 硫酸硝酸法》（HJ/T 299-2007）对处理效果进行评价，以及使用激光粒度仪、SEM和XPS对处理前后土壤样品的粒径、形貌以及铬的价态变化等性质进行表征。分析结果显示，机械化学还原法处理可以有效降低土壤中六价铬的浸出浓度。当未添加七水合硫酸亚铁时，土壤中六价铬的浸出浓度由115 mg·L-1降低至2.0 mg·L-1；而添加七水合硫酸亚铁作为还原剂时，六价铬浸出浓度由115 mg·L-1降至0.16 mg·L-1。另外，经过机械化学还原处理后的土壤样品颗粒变细并形成致密的团聚体以及发生六价铬向三价铬的转化。

English Abstract

    全文HTML

参考文献 (23)

目录

/

返回文章
返回

Copyright © 2019 中国科学院生态环境研究中心